
![]() |
Mark Sennett
Managing Editor |
![]() |
Kelly Rose
Editor |
Home> | Handling & Storing | >General Handling | >Drinks giant fined after worker sustains burns |
Home> | Premises | >Risk Management | >Drinks giant fined after worker sustains burns |
Drinks giant fined after worker sustains burns
03 February 2025
AN INTERNATIONAL drinks manufacturer has been fined half a million pounds after an employee sustained burns to over 30% of his body.

The mechanical engineer had been repairing a defective pump at Diageo’s Glenlossie Distillery Complex in Elgin on 24 March 2021 when he was burned by pot ale.
The liquid, which had a temperature of 104 degrees Celsius, came out suddenly and unexpectedly from a pipe.
The worker sustained burns to his arms, hands, shoulders, back, chest, lower legs and ankles, before spending two weeks in intensive care where he was placed in an induced coma.
A Health and Safety Executive (HSE) investigation found Diageo failed to do all that was reasonably practicable to ensure maintenance operations could be carried out without a worker being put at risk of injury.
HSE guidance on the safe isolation of plant and equipment is freely available and provides steps to prevent the release of substances that are hazardous including hot, flammable and toxic substances. The guidance can be found at The safe isolation of plant and equipment – HSG253.
Diageo Scotland Limited, of Lochside Place, Edinburgh, pleaded guilty to breaching Sections 2(1), 2(2)(a), 2(2)(c), 33(1)(a) and 33(1)(c) of the Health and Safety at Work etc. Act 1974. The company was fined £500,000 at Inverness Sheriff Court on 16 December 2024.
HSE inspector Isabelle Martin said, “This incident could so easily have been avoided by ensuring that procedures were in place to ensure that changes to work equipment installed in the plant were safe. However, more importantly Diageo should have had procedures in place to ensure that plant could be isolated safely and prevent the release of hazardous and dangerous substances.
“Companies should be aware that HSE will not hesitate to take appropriate enforcement action against those that fall below the required standards.”
- Worker falls while cleaning windows
- Lighthouse Charity lights up wellbeing learning
- Engineering firm fined after apprentice loses fingers
- Council fined following fatality due to falling branch
- Don't delay overdue eye tests
- Online tools to 'reduce burden' on small businesses
- Farmer fined after cows attack retiree
- BSC reopens offer of free wellbeing support to SMEs
- PPE Insights Guide 2024
- Lord Young recommends quick and easy DIY risk analysis for SMEs